Product ID:WD-40 AEROSOL
MSDS Date:01/01/1989
FSC:8030
NIIN:01-021-3203
MSDS Number: BGFBQ

WD-40 COMPANY

1061 CUDAHY PLACE (92110)
SAN DIEGO, CA 92138-9021
US

Emergency Phone: 619-275-1400

Info Phone: 619-275-1400

Preparer: R. MILES,TECH. DIRECTOR

Cage: 09137

WD-40 COMPANY

80607 SAN DIEGO, CA 92138-0607 US

Telephone: 619-275-1400

Cage: 09137

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 50%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

MINERAL OIL (PETROLEUM BASE OIL)

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: >15%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

CORROSION INHIBITOR (PROPIETARY MIXTURE)

Fraction By Weight: <10%

CORROSION INHIBITOR (TYPE NOT SPECIFIED-PROPIETARY)

Fraction By Weight: <10%

WETTING AGENT (TYPE NOT SPECIFIED-PROPIETARY)

Fraction By Weight: <5%

FRAGRANCE (TYPE NOT SPECIFIED)

Fraction By Weight: <5%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:THIS PRODUCT IS AN INHALATION HAZARD.
EYE OR SKIN CONTACT MAY CAUSE IRRITATION.
Effects of Overexposure:EYES:IRRITATION,TEARING,REDNESS.
SKIN:IRRITATION,DRYING.
INHALATION:ANESTHESIA,HEADACHE,DIZZINESS,NAUSEA,UPPER RESPIRATORY
IRRITATION. INGESTION:IRRITATION,NAUSEA,VOMITING,DIARRHEA.
ASPIRTATION INTO L UNGS:CHEMICAL PNEUMONITIS.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH A HISTORY OF
RESPIRATORY CONDITIONS MAY BE AT INCREASED RISK.

First Aid:EYES:FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.IF IRRITATION
PERSISTS SEE DOCTOR. SKIN:WASH WITH SOAP AND WATER.IF IRRITATION
PERSISTS.SEE DOCTOR. INHALATION:REMOVE TO FRESH AIR.GIVE OXYGEN/CPR
IF NEE DED,SEE DOCTOR. INGESTION:DO NOT INDUCEVOMIT.SEEK MEDICAL
ATTENTION.

Lower Limits:1.8
Upper Limits:9.5
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:USE EXTRA CARE. EXTREMELY FLAMMABLE.
CONTAINER MAY EXPLODE ON HEAT OF FIRE.

Spill Release Procedures:SPILL IS UNLIKELY FROM AEROSOL CANS. LEAKING
CANS SHOULD BE PLACED IN PLASTIC BAG OR OPEN PAIL UNTIL PRESSURE
HAS DISSIPATED. KEEP AREA WELL VENTILATED.

Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED,LOW
FIRE RISK AREA.PROTECT CONTAINER FROM PHYSICAL DAMAGE.DO NOT STORE
ABOVE 120F(49C).
Other Precautions:KEEP AT ROOM TEMPERATURE AS EXPOSURE TO SUNLIGHT MAY
CAUSE BURSTING. KEEP AWAY FROM IGNITION SOURCES AND INCOMPATIBLE
MATERIALS.AVOID EXCESSIVE INHALATION OF SPRAY PARTICLES. DO NOT
PUNCTURE OR INCINE RATE. DO NOT TAKE INTERNALLY.

Respiratory Protection:NONE NORMALLY REQUIRED WITH GOOD VENTILATION.
NIOSH/MSHA-APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE IF TLV
IS EXCEEDED.
Ventilation:MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST TO MAINTAIN
EXPOSURE BELOW TLV.
Protective Gloves:RUBBER.
Eye Protection:CHEMICAL SAFETY GOGGLES.
Other Protective Equipment:AS NECESSARY TO PREVENT PROLONGED CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.

Vapor Pres:3603
Vapor Density:>1
Spec Gravity:0.710
Solubility in Water:INSOLUBLE.
Appearance and Odor:LIGHT AMBER LIQUID, CHARACTERISTIC ODOR.
Percent Volatiles by Volume:80

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
INCOMPLETELY BURNED CARBON PRODUCTS.

Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.DO NOT
PUNCTURE OR INCINERATE CONTAINER.GIVE TO DISPOSAL SERVICE.DISPOSE
OF IN ACCORDANCE WITH FEDERAL,STATE AND LOCAL ENVIRONMENTAL
REGULATIONS.FULL OR PARTIA LLY FILLED CONTAINERS ARE CONSIDERED
HAZARDOUS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.